Synchronized in 2nd,3rd, and 4th, with 1st and reverse non-synchronized. Synchronized in all forward speeds with 4th being overdrive. Please… According to Autozone the capacity is 3. Some say that the Ford reccommended transmission oil for a '91 4-speed is an 80w gear lube. If you don't have an owner's manual, either get one or call your local Ford dealer for the proper lubricant. In 1979, Ford acquired a 25-percent stake in Mazda.
The engine in your 1994 Ford F-150 should be running when you perform a transmission fluid level check, otherwise it will be inaccurate. Check your owners manual or call the dealer. Produced in 2 and 4 wheel drive versions. This unit was produced for cars also but with lighter duty bearings and gear train. We sell only high quality used Ford F-150 automatic transmissions, with 1-3 years warranty and free shipping. Case casting number is 1309. .
Mazda produced the fully synchronized transmission for two- and four-wheel drive 1992 F-150s. Older Ford Rangers for instance come equipped with 2 different manual transmissions, one a Ford Transmission and the other a Mazda. A unique feature of this unit is an internal oil pump driven off the front of the countershaft that circulates the lube to a trans cooler. Shortly after, you will receive price quotes directly from the sellers that stock the transmission. Used in 1978-84 Ford light duty pickups and vans. Remove the cap and there should be a tube under it you can pour the fluid in.
The Borg-Warner T-18, which Ford used in its trucks since 1956, remained in Ford's transmission lineup until 1992. The transmission uses a hydraulic clutch setup and has an internal slave cylinder, which is a source of frustration for anyone having a slave cylinder failure, as it requires the entire transmission to be removed. How ever if you don't have that available if the transmission case is made from aluminum Mercon V is required and if the case is made from cast iron then gear oil 90W-120W is needed. Using the wrong lubricant can cause serious damage to the transmission. There are two plugs, make sure you take off the top one, the bottom one is to drain it, top to check it of course.
Fill until lube comes out the fill hole. Call a couple of local garages. Aluminum case and shift tower. Our discount used 1991 Ford F-150 transmissions come directly from a dependable network of modern junk yards. The Fill plug is also on the drivers side about half way up and is the same size as the Drain Plug. Change Your Mind, Not Your Oil.
If you don't have an owners manual, pickup a repair manual for your car, which will tell you just about everything about your car. Some Manual Transmission oils are multigrade, e. The plug is the same size and shape as the drain plug in the bottom of the case. Most of the 5-speed trannys have a fill plug located on the forward, driver's side of the tranny. The price differs with the part of the country you live in.
The same vehicle could have a slightly different transmission model and use a different fluid. But If you plan on keeping it I would suggest putting some red line manual transmission additive in every time… It will take gear oil found at any automotive store, make sure it is manual tranny oil and not automatic tranny fluid. I'm not an expert on Ford transmissions, but, the C4 is usually considered a lighter duty transmission as it is used in cars for the most part, the C6 however, is used in Pick up trucks and high performance cars of the time period. There are 2 types of trans-ax5 wich holds 3. Make sure you install the correct lube. Synchronized in all forward gears, with top loaded cast iron case. We will not process your order before verifying with you the engine information! Id tags are mounted on the left side of the main case.
First, start with the drive shaft, then the transfer case, and then the front cross member holding up the front axle or shift on the fly hub locker. In contrast, the four-speed T-18 had a 6. Check your owners manual and it should tell you what viscosity weight ,or thickness the factory recommends to get example 80w or 90w. The video above shows where the transmission fluid dipstick is located in your F-150 and how to check the transmission fluid level. Place pump hose into hole and fill. Great care should be taken to properly identify the unit you are working on as both the S542 and S547 appear to be the same and with the great variety of ratios available, it is easy to order the wrong parts. Tie up the transfer case to the cross member that is right behind it because at this time you can not take it out.
There is also a passenger car version of this unit with lighter duty bearings and gear ratios. Your owner's manual will tell you what your transmission calls for. This unit has an aluminum case with integral bell housing, a center support, and rear case. Great care should be taken to properly identify the unit you are working on as both the S542 and S547 appear to be the same and with the great variety of ratios available, it is easy to order the wrong parts. Be very careful not to drop anything in there! But either… Generic instructions and I'm assuming a 5 speed manual trans. I would say, depending on your needs, the C6 is the better transmission. The Mazda transmission had a 3.
Aluminum case, extension housing, and shift cover, with integral bell housing. Just look at the transmission and see what needs to come off. F-150 1988-Up M5R2 Mazda built 5 speed fully synchronized transmission found in 1988 to present Ford F150 series trucks and full size Broncos. Produced in 2 and 4 wheel drive versions. Plug is a pipe fitting style thread, do not overtighten. Very similar in design to M5R1, but larger with shift lever located in center of shift cover.